Mels Canned Hickory Honey Ham Recipes

PINEAPPLE HONEY-GLAZED HAM

Steps:

• Let the ham sit at room temperature for about 30 minutes.
• Preheat the oven to 325 degrees F.
• Trim off any skin from the ham. Use a sharp paring knife to score through the fat in a diagonal crosshatch pattern without cutting through to the meat. Push the cloves into the ham, if using, placing them at the intersections of the cuts. Put the ham, flat-side down, on a rack in a roasting pan.
• Drain the pineapples, reserving the juice. Arrange the sliced pineapple all over the ham, securing with toothpicks. Add a maraschino cherry to the center of each pineapple slice and secure with a toothpick.
• Pour 1/4 inch water in the bottom of the pan and tent the ham with foil.
• Roast until an instant-read thermometer inserted in the thickest part of the ham (avoiding bone) registers 130 degrees F, about 2 hours 30 minutes (or about 15 minutes per pound).
• Meanwhile, combine the honey, brown sugar and reserved pineapple juice in a large saucepan set over medium heat. Simmer, stirring occasionally, until thickened, syrupy and reduced to about 3 cups, 25 to 30 minutes. Set aside.
• Increase the oven temperature to 425 degrees F.
• Uncover the pan and carefully brush a third of the glaze all over the ham. If the water in the roasting pan has evaporated, add more. Bake the ham for 15 minutes more. Brush with another third of the glaze and bake for 15 minutes more. Brush the remaining glaze over the ham and cook until the glaze is shiny and the skin is dark golden brown and crispy, about 15 minutes more. Let rest for 15 minutes.

HONEY-CURED, HICKORY-SMOKED SHOULDER HAM

Steps:

• Make the brine: In a large pot, place 2 1/2 quarts water, the salt, honey, brown sugar and Prague powder. Bring to a boil over high, stirring until the salt, honey and sugar are dissolved.
• Make the spice bundle: Tie the cloves, allspice berries, bay leaves, lemon zest and peppercorns in a piece of cheesecloth.
• Stir the spice bundle and another 2 1/2 quarts ice water into the brine, remove from heat and let the mixture cool to room temperature (about 30 minutes).
• While the brine cools, prepare the ham: Using paper towels, blot the pork shoulder dry on all sides. Using a sharp knife, score the ham in a crosshatch pattern, cutting through the skin but not through the meat and spacing the cuts 1 1/2 inches apart. (This is optional, as you'll remove the skin, but it facilitates injecting and gives the ham a striking appearance.)
• Measure out 2 cups brine and place in a deep measuring cup. Place the ham in a roasting pan. Draw the brine into a marinade injector and inject it deep into the ham all over, inserting the needle at 1 1/2-inch intervals and drawing it out slowly as you depress the plunger, until the brine starts to squirt out of the surface of the ham.
• Place the ham in a large pot or food-safe bucket with a lid, or 3-gallon resealable plastic bag. Add the brine and flavorings (plus any brine in the roasting pan). If using a plastic bag, tightly seal, squeezing out any air, and place the bag in the roasting pan to corral any leaks. Brine the ham in the refrigerator for 3 days, turning the ham twice a day so it cures evenly.
• Pour the brine into a large pot and set aside. Remove the ham from its pot or bag and transfer it to a roasting pan. Using the marinade injector, re-inject the ham with brine (using 2 cups again, or more, if you can get more in), inserting the needle at 1 1/2-inch intervals. Return the ham and all the brine to the bag. (You can use a fresh bag, if you wish.) Continue brining the ham in the refrigerator for another 3 days, turning twice a day so it brines evenly. When ready for smoking, the meat will take on a pinkish hue.
• Drain the ham in a large colander, discarding the brine. Rinse the ham well with cold water, drain again and blot dry with paper towels. Place it on a wire rack over a roasting pan and let it dry for 2 to 3 hours in the refrigerator.
• If using a charcoal grill, set it up for indirect grilling and heat it to 250 degrees. If using wood chips, soak them in water to cover for 30 minutes, then drain. If using wood chunks, there is no need to soak them. (With a kettle grill, use less charcoal than normal to obtain this low temperature.) If using a smoker, heat it to 250 degrees following the manufacturer's instructions.
• Place the ham on the grate, fat-side up, using indirect heat, and add 1 1/2 cups wood chips or 2 wood chunks to the coals. Smoke the ham until handsomely browned and cooked through. (The internal temperature will be about 160 degrees.) This typically takes about 7 hours, but you may need more or less time, depending on your ham, smoker and the weather. Add wood chips (about 1 1/2 cups) or chunks (1 large or 2 medium) per hour to the embers to maintain a constant flow of smoke. Rotate your ham a few times during cooking so that it browns evenly, and drape it loosely with foil if it seems to be darkening too much.
• Transfer the ham to a cutting board and let it cool for 20 minutes. Pull off the skin. (If you're feeling ambitious, you can fry the skin in 350-degree oil to make smoke-flavored cracklings.)
• Thinly slice the ham across the grain and serve. You can serve the ham hot, at room temperature, or chilled. Refrigerated, it will keep for at least a week.

HONEY HAM

Steps:

• Choose a pot that fits the ham with enough space on top to close its lid and with space between the ham and the sides. Combine the wine, juniper berries, peppercorns, cloves and 2 tablespoons honey in the pot, and mix well. Arrange the onion in the center to form a rack for the ham and place the ham on top, flat side down. It should sit just above the wine.
• Bring to a boil over medium-high heat, then reduce the heat to low, cover and simmer, basting after 15 minutes, until the ham is heated through, 30 to 40 minutes.
• Meanwhile, heat the oven to 450 degrees. Line a sheet pan with foil. Combine the brown sugar, mustard and remaining tablespoon honey in a small bowl.
• Carefully transfer the ham to the foil-lined pan using 2 sturdy metal spatulas. The slices should have fanned open. If they haven't, separate the slices, nudging them into a pretty arrangement. Add 1 tablespoon cooking liquid from the pot to the brown sugar mixture and stir until smooth. (Save the remaining cooking liquid for stews or braises.) Pour over the ham, spreading evenly all over the top and not letting too much spill onto the foil. Fold up the sides of the foil to form a little boat to hold any ham juices.
• Bake just until the topping is crackling and caramelized, 10 to 15 minutes. Carefully transfer to a serving platter with the spatulas, then pour the juices from the foil all over the ham. Serve immediately, with the onions from the pot, if you'd like.