Grilled Cubano Recipes

CUBAN SANDWICH (CUBANO)

Steps:

• Heat your skillet or griddle: I like to use two cast iron skillets nested on top of one another, pressing the sandwich in between. To use this method, place both skillets (one on top of the other) over medium heat and let them heat through. If using a panini press set it to medium heat. The skillet or griddle shouldn't be screaming hot, but it should radiate enough heat to toast the bread slowly. If you aren't using the double pan method or a panini press, just use anything you have to weigh the sandwich down - a foil wrapped brick, your spatula, whatever you have will do.
• Serve: Remove your sandwich from the skillet or griddle. Slice your sandwich according to the number of guests you need to serve and serve the sandwich with a handful of chips and a pickle or two. LEFTOVERS! Leftovers should be wrapped in foil and stored in the refrigerator. They may be reheated by cooking the same as above.

CUBANO SANDWICH

Steps:

• Preheat a sandwich press to medium heat.
• Drizzle the onion and pepper with the olive oil and season with salt and pepper. Put the onion and pepper on the sandwich press, close and cook until tender and lightly browned, 8 to 10 minutes. Slice into strips.
• Brush the outside of the bottom half of the bread with some of the melted butter. Brush the inside of both halves with a generous amount of the Mojo Mustard. On the bottom half of the bread, layer the sliced deli ham and top with the carnitas. Top with the gherkins, grilled onion and peppers and finally the cheese. Top with the top half of the bread and brush with more butter. Slice in half widthwise.
• Place both halves in the sandwich press, close, press down and cook until the bread is crispy and the cheese is melted, 5 to 7 minutes. Cut in half to make 4 sandwiches.
• Mix together the mustard, honey, chili paste, oregano, cumin, orange zest and juice, lime zest and juice, garlic and some salt and pepper in a bowl.
• Set the slow cooker to high. Put the pork cubes in the slow cooker and season all over with the chipotle powder and some salt. Turn any pieces with the fat cap upright. Nestle in the garlic, cinnamon sticks and yellow onion. Pour the orange soda, vegetable oil and orange juice and zest over the pork. Cover and cook on high until super tender, about 4 hours.
• Preheat the oven to broil.
• Transfer the pork chunks to a baking sheet fat-side up. Let the liquid in the slow cooker settle so the fat is on the surface. Scoop off about 1/4 cup of the fat and drizzle over the pork chunks. Broil until the meat is crispy and the fat is bubbly, 1 to 2 minutes.

GRILLED CUBAN SANDWICH (SANDWICH CUBANO)

Steps:

• Assemble the sandwich
• Spread 2 tablespoons of the butter on one half of the bread loaf and a thin layer of mustard on the other. Place 1 to 2 layers of ham, pork, cheese, and, finally, pickles on the buttered bread and top with the mustard-spread bread.
• Wrap the sandwich in foil
• Smear the remaining butter all over the outside of the sandwich and wrap it completely in aluminum foil.
• Press and grill the sandwich
• Heat your grill to high (550°F) and close the lid. Wait at least 15 minutes before lowering the heat to medium-high (450°F) and continuing.
• Before grilling the sandwich, press down on it with your hands to flatten it. Place the wrapped, flattened sandwich on the grill and top with a brick, grill press, or any other heavy, heat-resistant object. Close the lid and grill for 5 to 6 minutes per side.
• Remove the wrapped sandwich from the grill and take off the foil. Return the sandwich to the grill and grill for about 2 to 3 minutes per side, or until both pieces of bread are crispy and golden brown.
• Slice and serve
• Remove the sandwich from the grill and cut at an angle into small sandwich wedges (triangles). Place on a large platter and serve while still hot.

CUBAN GRILLED PORK (LECHON ASADO)

Steps:

• Prepare the marinade
• Mix all marinade ingredients in a bowl and let sit for 10 minutes.
• Marinate the pork
• If using a flavor injector (see cooking notes), strain half the marinade into a bowl, adding the strained-out garlic to the other half of the marinade. Use the injector to take in some strained marinade, pierce the pork with the tip of the needle, and inject it into the flesh. Do this all over the meat until the strained marinade has been used up.
• If you are not using a flavor injector, use a long, thin knife to create deep gashes all over the flesh and pour the marinade over the pork.
• Place the marinated pork in a deep bowl or container. Generously season the outside of the pork with salt and pour the remaining marinade all over it, spreading the onion rings all over the top.
• Cover well with plastic wrap and refrigerate for at least 1 hour or up to 24 hours.
• Boil the marinade for basting
• Remove the pork from the marinade and place it on a platter. Transfer the marinade to a saucepan, add the onions, and bring to a boil for 2 minutes. Remove from the heat and allow to cool. Place the boiled marinade and onions in a blender and puree until smooth. The marinade is now ready to use as a basting liquid.
• Grill the pork
• Before heating your grill, remove the pork from the refrigerator and bring to room temperature.
• Heat your grill to 550°F and close the lid. Wait at least 15 minutes before lowering the temperature to 300°F. Oil the grill grates with a vegetable oil-soaked paper towel held with a long pair of tongs.
• If your cut has the skin still attached, begin the cooking process with the skin side up (away from the direct heat).
• Grill your meat about 2 1/2 hours total. Turn the meat over once when you are one quarter through with the cooking time, again when you are halfway through, and once more when three-quarters of the cooking time has elapsed. The pork is ready when it reaches an internal temperature of 150°F on the grill (it will continue to cook when it's off the heat, raising the internal temperature to the desired 160°F).

CHEF JOHN'S CUBAN SANDWICH

Steps:

• Mix mayonnaise, mustard, and cayenne together in a bowl to make the sauce.
• Trim off ends of bread. Cut loaf in half and evenly split bread to make tops and bottoms of 2 sandwiches. Spread each half on both sides generously with the mayo/mustard sauce.
• Divide sandwich ingredients between the two bottom halves in this order: 2 slices Swiss cheese, 3 slices ham, hot cooked pork, pickle slices, and 2 more slices of Swiss cheese. Place tops on sandwiches.
• Melt butter in a heavy skillet over medium heat. Place sandwiches in skillet and press down with a heavy weight (such as another skillet or foil-wrapped bricks). Toast sandwiches until bread is crisp and filling is heated through, 3 or 4 minutes per side.

GRILLED CUBANO

Steps:

• Preheat grill to medium. Brush pork with oil; season with salt and pepper. Brush grates with oil. Grill pork, flipping once, until cooked through and lightly charred, about 3 minutes; transfer to a plate.
• Scoop out soft insides of bread, leaving a 1/8-inch border. Spread mayonnaise and Dijon on opposite halves, then sandwich cheese, pork, ham, and pickles with bread.
• Brush oil over both sides of bread. Grill, weighting with a large cast-iron skillet and flipping once, until cheese is melted and bread is lightly marked, 8 to 10 minutes. Transfer to a cutting board; slice into 8 pieces. Serve immediately, with chips.

GRILLED CUBAN SANDWICH

Steps:

• Assemble the sandwich.
• Spread 2 tablespoons of the butter on one half of the bread loaf and a thin layer of mustard on the other. Place 1 to 2 layers of ham, pork, cheese, and, finally, pickles on the buttered bread and top with the mustard-spread bread.
• Wrap the sandwich in foil.
• Smear the remaining butter all over the outside of the sandwich and wrap it completely in aluminum foil.
• Press and grill the sandwich.
• Heat your grill to high (550°F) and close the lid. Wait at least 15 minutes before lowering the heat to medium-high (450°F) and continuing.
• Before grilling the sandwich, press down on it with your hands to flatten it. Place the wrapped, flattened sandwich on the grill and top with a brick, grill press, or any other heavy, heat-resistant object. Close the lid and grill for 5 to 6 minutes per side.
• Remove the wrapped sandwich from the grill and take off the foil. Return the sandwich to the grill and grill for about 2 to 3 minutes per side, or until both pieces of bread are crispy and golden brown.
• Slice and serve.
• Remove the sandwich from the grill and cut at an angle into small sandwich wedges (triangles). Place on a large platter and serve while still hot.
• NOTES:.
• The loaf sandwich can be prepared and wrapped in foil a few hours in advance. Press and grill right before serving.
• Instead of plan mustard I like to mix mustard, mayonnaise and some cayenne pepper together to give it a little more flavor.