Cured Pork Shoulder Recipes

PORK ROAST WITH CRISPY PORK CRACKLING

Steps:

• Dry skin: Pat the skin dry with paper towels. If time permits, leave in the fridge uncovered overnight (even 1 hr helps). If not, pat extra well.
• Preheat oven to 220°C/430°F (200°C fan).
• Season flesh: Sprinkle pork flesh with 1 1/2 tsp salt, all the pepper and all fennel seeds and 1 tbsp olive oil. Rub into flesh, right into all the crevices and cracks.
• Salt skin: Flip pork, drizzle skin with 1 tsp oil, then rub all over with fingers. Sprinkle all over with remaining 1 1/2 tsp salt, taking care to get even coverage. Un-salted patches will not become bubbly crackling, it will be a hard flat sheet.
• Garlic & onion bed: Place halved garlic bulbs and onion in roasting pan. Place pork skin side up on top of them.
• Wine: Carefully pour wine into the pan, being sure not to wet the skin. Transfer to oven.
• Lower oven: Immediately turn oven down to 160°C/320°F (140°C fan).
• Slow roast: Roast for 2 1/2 hours.
• Level at 1 1/2 hours: Check pork after 1 1/2 hours to see if the pork is warped and the skin's overall surface is significantly unlevelled. If so, adjust to make the skin surface as level as possible using balls of foil and moving large dislodged pork pieces to the side (key tip for crispy crackling, Note 3). Then return to oven for the remaining 1 hour.
• Check pan & salt on skin: If pan is drying out, add some water. If there are bald patches on the skin without salt (eg it fell off), spray lightly with oil spray (or brush lightly with oil) then sprinkle with salt. (Remember, salt = bubbly skin!)
• Increase heat: Turn oven up to 250°C/485°F (all oven types), or as high as it will go if your oven won't go this high.
• Make skin crisp: Return pork to oven for 30 minutes, rotating pan as needed, until skin is crisp and bubbly all over. If needed, use foil patches, secured with water soaked toothpicks, to cover parts that are done and keep crisping up remaining patches.
• Rest: Transfer pork to serving platter, tent loosely with foil (don't worry, crackling stays super-crisp) and rest for 20 minutes (stays warm up to 1 hour). Then slice using a serrated knife.
• Serve with gravy. Don't pour gravy over crackling - pour it off to the side! See note for reheating.

MOLASSES-CURED PORK SHOULDER BACON

Steps:

• Put pork butt, fat side up, on a work surface, then halve horizontally with a sharp large knife.
• Stir together water, salt, brown sugar, and Instacure in storage tub until solids are dissolved, about 3 minutes, then add molasses and stir until dissolved. Add ice and stir until cure is cold (ice may not be completely melted; keeping liquid cold slows salt absorption).
• Add pork to cure, then weight with a large plate to keep submerged. Chill, tub covered with a lid or plastic wrap, 36 hours.
• Rinse pork and pat dry, then discard brine. Sprinkle pork evenly with pepper (if using).
• Prepare grill and smoke bacon: See preceding recipe.
• Cut bacon crosswise into 1/8-inch-thick slices with a sharp knife, then fry in a heavy skillet over moderately low heat, turning, until browned. Transfer to paper towels to drain.
• Available at The Sausage Maker (888-490-8525).

HONEY-CURED, HICKORY-SMOKED SHOULDER HAM

Steps:

• Make the brine: In a large pot, place 2 1/2 quarts water, the salt, honey, brown sugar and Prague powder. Bring to a boil over high, stirring until the salt, honey and sugar are dissolved.
• Make the spice bundle: Tie the cloves, allspice berries, bay leaves, lemon zest and peppercorns in a piece of cheesecloth.
• Stir the spice bundle and another 2 1/2 quarts ice water into the brine, remove from heat and let the mixture cool to room temperature (about 30 minutes).
• While the brine cools, prepare the ham: Using paper towels, blot the pork shoulder dry on all sides. Using a sharp knife, score the ham in a crosshatch pattern, cutting through the skin but not through the meat and spacing the cuts 1 1/2 inches apart. (This is optional, as you'll remove the skin, but it facilitates injecting and gives the ham a striking appearance.)
• Measure out 2 cups brine and place in a deep measuring cup. Place the ham in a roasting pan. Draw the brine into a marinade injector and inject it deep into the ham all over, inserting the needle at 1 1/2-inch intervals and drawing it out slowly as you depress the plunger, until the brine starts to squirt out of the surface of the ham.
• Place the ham in a large pot or food-safe bucket with a lid, or 3-gallon resealable plastic bag. Add the brine and flavorings (plus any brine in the roasting pan). If using a plastic bag, tightly seal, squeezing out any air, and place the bag in the roasting pan to corral any leaks. Brine the ham in the refrigerator for 3 days, turning the ham twice a day so it cures evenly.
• Pour the brine into a large pot and set aside. Remove the ham from its pot or bag and transfer it to a roasting pan. Using the marinade injector, re-inject the ham with brine (using 2 cups again, or more, if you can get more in), inserting the needle at 1 1/2-inch intervals. Return the ham and all the brine to the bag. (You can use a fresh bag, if you wish.) Continue brining the ham in the refrigerator for another 3 days, turning twice a day so it brines evenly. When ready for smoking, the meat will take on a pinkish hue.
• Drain the ham in a large colander, discarding the brine. Rinse the ham well with cold water, drain again and blot dry with paper towels. Place it on a wire rack over a roasting pan and let it dry for 2 to 3 hours in the refrigerator.
• If using a charcoal grill, set it up for indirect grilling and heat it to 250 degrees. If using wood chips, soak them in water to cover for 30 minutes, then drain. If using wood chunks, there is no need to soak them. (With a kettle grill, use less charcoal than normal to obtain this low temperature.) If using a smoker, heat it to 250 degrees following the manufacturer's instructions.
• Place the ham on the grate, fat-side up, using indirect heat, and add 1 1/2 cups wood chips or 2 wood chunks to the coals. Smoke the ham until handsomely browned and cooked through. (The internal temperature will be about 160 degrees.) This typically takes about 7 hours, but you may need more or less time, depending on your ham, smoker and the weather. Add wood chips (about 1 1/2 cups) or chunks (1 large or 2 medium) per hour to the embers to maintain a constant flow of smoke. Rotate your ham a few times during cooking so that it browns evenly, and drape it loosely with foil if it seems to be darkening too much.
• Transfer the ham to a cutting board and let it cool for 20 minutes. Pull off the skin. (If you're feeling ambitious, you can fry the skin in 350-degree oil to make smoke-flavored cracklings.)
• Thinly slice the ham across the grain and serve. You can serve the ham hot, at room temperature, or chilled. Refrigerated, it will keep for at least a week.