Italian Porchetta Sandwich Recipes

PORCHETTA (AUTHENTIC ITALIAN PORK ROAST)

Steps:

• Open the piece of pork onto the butcher paper or clean countertop, skin side down.
• Sprinkle generously with the salt, then work the salt into the pork.
• Next, add the rosemary. We used fresh rosemary as I have a bush in my garden. Rub it and crush it between your fingers to release the oils.Add the freshly ground black pepper all over the porchetta. Now add the fennel pollen. Sprinkle evenly over the pork, but save a little of the pollen for after the porchetta has been rolled.
• Roll it tightly, but as you roll it, sprinkly some salt onto the unseasoned pork. Continue rolling until you reach the end.
• Keeping the seam side down, start tying the pork. Another pair of hands will make this part immensely easier. There's no need for fancy ties or sailors' knots, just wrap, double knot and cut.
• Repeat every few inches. The goal is only to keep the porchetta closed, so don't tie it too tightly, either. As you can see, ours is far from perfect, but unless you're serving the Queen of England, it won't matter.
• Turn the roast seam side up and add more seasonings, including the rest of the fennel pollen to the non-skin parts of the pork which are exposed (including the ends).
• Place seam side down on a rack on a roasting pan or baking tray. Cover the ends with aluminum foil and secure with toothpicks.
• Drizzle with olive oil and rub all over the skin with your hands. Sprinkle with more salt and rosemary.
• Preheat the oven to 400˚F (200˚C).
• Place in the hot oven when it comes to temperature and roast for 1 hour, then lower the temperature to 350°F (170°C) and continue to cook for about another 2 hours. Check the center of the roast when it reaches 170°F (76°C) remove from the oven. Take the foil off the ends and place on top of the porchetta, and allow to rest for about 10 minutes.
• Using a sharp knife, remove one or two of the pieces of twine. Cut into slices and serve on crusty Italian rolls, or bread, Italian style!

PORCHETTA - ITALIAN MARKETPLACE SLOW ROAST PULLED PORK SANDWICH

Steps:

• Lay the pork on a large chopping board and cover with cling film. With a rolling pin, mallet, or other suitable blunt object, pound the meat as close to an even 1" thickness that you can manage.
• Heat 2 tablespoons of the olive oil in a frying pan over a medium high. Add all of the chopped onion, half the minced garlic, half the fennel seeds, all of the rosemary and bay, half of the ground cloves, salt and pepper, and cook for 2 to 3 minutes, or until all the fragrance has been released from the herbs and spices. Transfer to a plate to cool.
• Spread and rub this mixture over and into the pork, then roll the meat up as tightly and neatly as you can. Tie with kitchen string at intervals.
• Mix the remaining ingredients (minced garlic, fennel seeds, ground cloves, olive oil) and rub it over the outside of the pork. Cover it with cling film and refrigerate 24 hours, or at least overnight.
• Remove the meat 40 minutes before cooking to allow it to return to room temperature. Meanwhile, preheat the oven to 150C/300F Take the cling film off the pork and place the pork joint in to a roasting tin.
• Cook the pork for 4 hours to 5 hours, until it is falling apart when you test it with a knife or fork. If the spices on the surface start to char too badly (a little blackness is a good thing), tent foil loosely over the roast. (I find I need to cover it for the last hour of cooking.).
• CROCK POT - at this stage, cook the pork in a crock pot for 4 to 5 hours on high, or on automatic for up to 8 hours.
• Remove from the oven and leave to rest at least 30 minutes to one hour. Slice, pull or shred the meat and serve in warmed ciabatta rolls.

ITALIAN PORCHETTA SANDWICH

Steps:

• Preheat the oven to 275 degrees F.
• For the herb rub:.
• Add the garlic, fennel seeds and red pepper flakes to a food processor and pulse until finely chopped. Add the oregano, rosemary and thyme and pulse into a rustic paste. Season with salt. Reserve 2 tablespoons of the rub for the mayonnaise spread.
• For the pork:.
• Lay the pork belly on a cutting board, skin-side-up, and score the skin at 1-inch intervals, 1/2-inch deep with a sharp knife. Rotate the pork 90 degrees and score the skin again, to create a diamond pattern. Sprinkle generously with salt; be sure to get into all the crevices. Flip the pork over, sprinkle generously with salt, then rub the meat side with the herb rub. Roll the pork belly up as tightly as possible and tie it crosswise with butcher's twine at 2-inch intervals.
• Place the pork in a roasting pan fitted with a rack. Pour 1/2 cup water into the bottom of the pan. Roast the pork to an internal temperature of 150 degrees F, 2 1/2 to 3 hours. Check periodically to ensure there is still some liquid in the bottom of the pan and add a little water to prevent scorching. Baste the pork belly with pan drippings a couple of times during cooking.
• Once the pork reaches 150 degrees F, raise the oven to 475 degrees F and continue roasting until the skin is super crispy, 30 to 40 minutes. For even browning, flip the pork halfway through the second roasting period.
• Transfer the porchetta to a cutting board and let rest for 20 to 30 minutes.
• Remove the rack from the roasting pan and pour off all but 3 tablespoons of the pan drippings. Set the roasting pan on the stovetop over medium heat. Add the onions and saute until lightly caramelized, about 15 minutes. Season with salt and pepper.
• For the mayonnaise spread:.
• Mix together the mayonnaise, capers, parsley, lemon zest and juice and the reserved herb rub. Season with salt and pepper.
• Cut the porchetta into 1/4-inch-thick slices.
• To assemble the sandwich:.
• Slather both halves of a ciabatta roll with mayonnaise spread. Layer the bottom half with slices of porchetta and top with caramelized onions and arugula.

CHEF JOHN'S PORCHETTA

Steps:

• Place pork roast on a work surface. Use a sharp knife to make a lengthwise cut about 1 inch from the edge of the meat, slicing down but not cutting through. Open the meat flat along the cut. Keeping the knife parallel to the cutting board, continue to slice the roast open so you can unroll it into a large, flat piece. (You can also ask your butcher to butterfly the roast for you.) When the meat is unrolled, make small slashes through any connective tissue or extra-thick parts so the roast is as even in thickness as possible.
• Drizzle cut surface with 2 teaspoons olive oil. Rub oil into meat and generously season with 2 teaspoons kosher salt, black pepper, sage, rosemary, orange zest, garlic, and crushed fennel seeds. Press seasonings in firmly with your hand, roll up the pork roast, and tie the roast in several places with kitchen twine.
• Place the pork roast on a rack, set the rack on a plate, and sprinkle meat with remaining 1 teaspoon salt. Refrigerate the roast uncovered overnight to dry-age.
• Preheat oven to 450 degrees F (230 degrees C). Lightly oil a baking dish and place roast into dish. Rub meat with 2 teaspoons olive oil.
• Bake in the preheated oven until outside is seared, 15 minutes. Reduce oven heat to 250 degrees F (120 degrees C) and continue to roast until an instant-read meat thermometer inserted into the center of the roast reads 145 degrees F (65 degrees C), about 1 hour more. Loosely cover roast with foil and let rest for 10 minutes. Slice thinly to serve.
• Mash anchovy fillet in a small bowl and add red pepper flakes, white wine vinegar, and Italian parsley. Stir to combine. Serve drizzled on pork.

STUFFED PORCHETTA

Steps:

• Score the pork belly skin with a sharp knife in a cross pattern. Score down to just before where the skin meets the fat, rather than the fat itself. Bring a large saucepan of water to a simmer and add the bicarbonate of soda. Lower the pork into the water, poach gently for 5 mins, then remove it from the water and leave to cool to room temperature.
• Meanwhile, toast the fennel seeds and chilli flakes in a dry frying pan over a high heat for 1-2 mins, then tip into a bowl and leave to cool. Grind the spices in a spice grinder or with a pestle and mortar, then mix with 1 tbsp fine sea salt.
• Once the pork has cooled, turn it skin-side down and pierce the underside of the meat all over with a knife. Rub the meat with the spiced salt rub, cover and put it in the fridge for at least 8 hrs or overnight. Can be prepared 24 hours ahead.
• The next day, make your stuffing. Heat the olive oil in a non-stick frying pan and add the onion and fennel. Season and cook gently over a low heat for 10 mins. Add the coriander seeds and garlic, and cook for another 2 mins, then add the mince. Cook for 8-10 mins until the mince is browned. Set aside and leave to cool.
• Transfer the mince and onion mix to a bowl and add the sourdough, pine nuts, orange zest, apricots, herbs, lemon juice and nutmeg. Season well, then mix together thoroughly with your hands. Add the egg and mix again.
• Lie the pork belly on a board, skin-side down. Form the stuffing into a sausage shape running all the way down the middle of the belly. Wrap the sides of the belly around the stuffing and tie with butcher's string. Place seam-side down in a roasting tin, uncovered, and chill for at least 2 hrs, preferably overnight. You want the skin to dry out completely so that it crisps up when you roast it.
• To cook the pork, remove it from the fridge and leave it for at least 1 hr to come to room temperature before you cook it. Heat oven to 180C/160C fan/ gas 4 and cook the pork for about 2 hrs, turning the tin every 30 mins or so. After 2 hrs, turn the heat up to 220C/ 200C fan/gas 7 and cook for another 20 mins. When the pork is done, a thermometer pushed into its centre should read 77C. If the skin looks in danger of burning, cover it with foil - but only do this once it has crackled.
• Once the pork has cooked, remove from the oven and leave to rest for 30 mins. When you're ready to carve, put the pork on a big chopping board. Using a sharp knife, slice the meat into rounds.

PORCHETTA SANDWICH

Steps:

• Make the salsa verde: In a medium bowl, mix together shallot, parsley, chives, vinegar, oregano, and salt; whisk in olive oil until emulsified. Stir in mustard and lemon juice; set aside.
• Make the sandwich: Cover split sides of rolls with salsa verde. Place 3 porchetta slices and some of the crackling on one half of each of the rolls; top with arugula and sandwich together with remaining roll half; serve.